The vehicle's electrical equipment is protected by fuses and relays. Some of the fuses are located in the vehicle interior.
The electrical circuits of the power unit are located in the engine compartment fuse and relay box.
Depending on the vehicle's specification, the location and marking of the relays and fuses may vary.
The interior fuse and relay box is located on the left-hand side of the instrument panel.
Before replacing a blown fuse or relay, it is necessary to determine the cause of the blowout and rectify it.
To check or replace a fuse in the vehicle interior, we disconnect the negative terminal of the battery.
We open the cover of the fuse and relay box.
The fuse numbers are marked on the cover.
Using the tweezers located on the cover of the fuse and relay box, we remove the fuse, check it and, if necessary, replace it with one of the same rating.
The numbers of the fuses located in the vehicle interior are shown in Figure 3.
Fuse assignment in the interior fuse box
No. — Current rating “A” — Fuse assignment
- F1 — 20 — Windscreen wiper, wiper switch, tailgate window heating relay
- F2 — 5 — Instrument cluster, fuel pump relay, engine control unit (ECU), block of warning lamps for unfastened seat belts and airbag deactivation
- F3 — 10 — Brake light switch
- F4 — 10 — Diagnostic connector, immobiliser antenna unit, automatic transmission control selector, body electrical equipment control unit
- F5 — 5 — Automatic transmission, starter relay, transmission control unit
- F6 — Spare
- F7 — Spare
- F8 — Spare
- F9 — 10 — Instrument cluster, left-hand dipped headlight
- F10 — 10 — Right-hand dipped headlight
- F11 — 10 — Instrument cluster, left-hand main beam headlight
- F12 — 10 — Right-hand main beam headlight
- F13 — 30 — Rear door electric window motors
- F14 — 30 — Front door electric window motors
- F15 — 10 — ABS system control unit, acceleration sensors, steering wheel angle sensor
- F16 — 15 — Front seat electric heating
- F17 — 15 — Horn
- F18 — 10 — Left-hand front and rear position lamps
- F19 — 10 — Right-hand front and rear position lamps, glovebox illumination, instrument cluster illumination, hazard warning switch, heating (air conditioning) and ventilation system control unit, audio system, cigarette lighter, central locking switch, front door electric window switches, transmission mode switch, number plate lamps
- F20 — 7.5 — Rear fog lamp
- F21 — 5 — Exterior mirror electric heating
- F22 — Spare
- F23 — Spare
- F24 — 5 — Electric power steering pump (not used)
- F25 — 5 — Gas fuel supply system (not used)
- F26 — 5 — SRS system
- F27 — 20 — Tailgate wiper motor, acoustic warning device, TDC sensor, reverse light switch on manual transmission
- F28 — 15 — Interior electrical equipment control unit (energy-saving mode)
- F29 — 15 — Interior electrical equipment control unit, diagnostic connector
- F30 — 20 — Interior electrical equipment control unit
- F31 — 15 — Fog lamps, fog lamp relay
- F32 — 30 — Tailgate window heating
- F33 — Spare
- F34 — 15 — Transmission control unit
- F35 — Spare
- F36 — 30 — Heating, air conditioning and ventilation system motor
- F37 — 5 — Exterior rear-view mirror electric adjustment
- F38 — 15 — Audio system, cigarette lighter
- F39 — 10 — Heating, air conditioning and ventilation system motor relay
Engine compartment fuse and relay box
We press the clip and open the cover of the fuse and relay box.
We remove the cover.
The fuse numbers are marked on the cover.
Slightly rocking them, we remove, check and, if necessary, replace the relays.
Using the tweezers, we remove the fuse.
Some fuses can be removed by hand.
Fuse and relay assignment in the engine compartment fuse box, K4M engine
Relay/fuse board No. — Relay/fuse No. — Relay/fuse assignment
- 597-1 — F1 (50A), F2 (25A) — ABS and ESP system control unit
- 597-2 — F1 (50 or 40 A) — Engine cooling system radiator fan, air conditioning compressor clutch
- 597-3 — F1 (80 A) — Electric power steering pump
- 597-4 — F1 (60 A), F2 (60 A) — Exterior lighting switch
597-5
- F1 (80 A) — Interior auxiliary heater, auxiliary heater relay (not used)
- F2 (25 A) — Transmission control unit (all-wheel drive)
597-6
- F1 (30 A) — Low speed of the cooling system electric fan
- F2 (25 A) — Fuel pump
- F3 — Spare
- F4 (15 A) — Gas fuel supply system (not used)
- 597-7 — Air conditioning compressor electromagnetic clutch diode
299
- 231 (A) — Fog lamp relay
- — (B) — Not used
- 233 — Heater fan relay
1047
- 238 (A) — Injection lockout relay
- 236 (B) — Fuel pump relay
784
- 700 (A) — Electric fan low speed relay
- 474 (B) — Air conditioning compressor engagement relay
- 336 — Electric fan high speed relay
Fuse numbers for vehicles with F4R engine
Fuse and relay assignment in the engine compartment fuse box, F4R engine
Board No. — Relay/fuse No. — Relay/fuse assignment
- 597-1 — F1 (50 A), F2 (25 A) — ABS and ESP system control unit
- 597-2 — F1 (50 or 40A) — Engine cooling system radiator fan, air conditioning compressor clutch
- 597-3 — F1 (60 A), F2 (60 A) — Exterior lighting switch
597-4
- F1 (80 A) — Interior auxiliary heater, auxiliary heater relay
- F2 (25 A) — Transmission control unit (all-wheel drive)
597-5
- F1 (15/30A) — Low speed of the cooling system electric fan/air conditioning compressor electromagnetic clutch
- F2 (25 A) — Fuel pump
- F3 — Spare
- F4 (15 A) — Automatic transmission control unit
- 597-6 — Air conditioning compressor electromagnetic clutch diode
- 299 — 231 (A) — Fog lamp relay
- — (B) — Not used
- 233 — Heater fan relay
1047
- 238 (A) — Injection system lockout relay
- 236 (B) — Fuel pump relay
784
- 700 (A) — Electric fan low speed relay
- 474 (B) — Air conditioning compressor engagement relay
- 336 — Electric fan high speed relay
- 232 — Starter relay
